brake fluid CHRYSLER ASPEN HYBRID 2009 2.G Owners Manual

JOBNAME: 146224AspenHEV 2009 PAGE: 1 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/ibc
INTRODUCTION
The oil change indicator system will remind you
that it is time to take your vehicle in for scheduled
maintenance. Based on engine operation condi-
tion the oil change indicator message will illumi-
nate, this means that service is required for your
vehicle. Have your vehicle serviced as soon as
possible, within the next 800 km. The oil change
indicator message will not monitor the time since
the last oil change. Change your vehicles oil if it
has been 6 months since your last oil change even
if the oil change indicator message is NOT illu-
minated. Change your engine oil more often if
you drive your vehicle off-road for an extendedperiod of time.Under no circumstances should
oil change intervals exceed 10,000 km or
6 months, whichever comes first.Your dealer
will reset the oil change indicator message after
completing the scheduled oil change. If this
scheduled oil change is performed by someone
other than your dealer the message can be reset by
referring to the steps described in the Owner's
Manual.
The performance of all scheduled service work is
required to maintain your vehicle in good operat-
ing condition. Chrysler Canada Inc. reserves the
right to deny warranty coverage if the vehicle has
not been properly maintained. While we do not
insist that such work be performed by factory
authorized retailers, we strongly recommend that
an authorized Chrysler, Jeeptor Dodge Retailer
perform this work.AT EACH STOP FOR FUEL
²Check the engine oil level about 5 minutes
after a fully warmed engine is shut off. Check-
ing the oil level while the vehicle is on level
ground will improve the accuracy of the oil
level reading. Add oil only when the level is at
or below the ADD or MIN mark.
²Check the windshield washer solvent and add
if required.
ONCE A MONTH
²Check tire pressure and look for unusual wear
or damage.
²Inspect the battery and clean and tighten the
terminals as required.
²Check the fluid levels of coolant reservoir,
brake master cylinder, power steering and
transmission and add as needed.
²Check all lights and other electrical items for
correct operation.
²Check and clean wiper blades. Replace if
required.
AT EACH OIL CHANGE
²Change the engine oil filter.
²Inspect the brake hoses and lines.
VISUAL INSPECTIONS Ð
INSPECT FOR SIGNS OF COMPONENT
DETERIORATION AND PHYSICAL DAMAGE.
MAINTENANCEScheduled maintenance must be completed to provide the best vehicle
performance and reliability. The limited warranties in the warranty booklet DO NOT COVER
repairs required due to improper maintenance. We strongly suggest you keep track of scheduled
maintenance and keep receipts or other documents. Use only recommended MopartLubricants
and genuine MopartParts. In the event that a condition arises between maintenance intervals,
please contact your retailer. AVOID PROLONGED PERIODS OF IDLING.
NOTE: WHERE TIME (MONTHS) AND METRAGE ARE INDICATED, FOLLOW THE
INTERVAL THAT OCCURS FIRST.

JOBNAME: 146224AspenHEV 2009 PAGE: 11 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/intervals
Perform Maintenance At
60,000 km or 36 Months
oChange the engine oil and oil filter.Under no circumstances should the oil change
interval exceed 10 000 km or 6 months whichever occurs first.*
oRotate tires.
oInspect the engine air filter if using your vehicle in dusty or off-road conditions;
replace if necessary.
oInspect the front and rear axle fluid; change if using your vehicle for any of the
following: police, taxi, fleet, off-road or frequent trailer towing.
oInspect the brake linings; replace if necessary.
* Oil changes that are prompted by the oil change indicator system prior to this
schedule maintenance interval can be recorded in the oil change log section.
Perform Maintenance
At
36 Months or
60,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................

JOBNAME: 146224AspenHEV 2009 PAGE: 12 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/intervals
oChange the engine oil and oil filter.Under no circum-
stances should the oil change interval exceed 10 000 km
or 6 months whichever occurs first.*
oRotate tires.
oInspect the engine air filter if using your vehicle in dusty
or off-road conditions; replace if necessary.
oInspect the front and rear axle fluid; change if using your
vehicle for any of the following: police, taxi, fleet, off-road
or frequent trailer towing.
oInspect the brake linings; replace if necessary.
* Oil changes that are prompted by the oil change indicator
system prior to this schedule maintenance interval can be
recorded in the oil change log section.
Perform Maintenance At
60,000 km or 36 Months
Odometer Reading
Date
Repair Order No.
CHRYSLER
RETAILERSTAMP
Signature of authorized Chrysler Canada Retailer
................................................................................................

JOBNAME: 146224AspenHEV 2009 PAGE: 19 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/intervals
Perform Maintenance At
100,000 km or 60 Months
oChange the engine oil and oil filter.Under no circumstances should the oil change
interval exceed 10 000 km or 6 months whichever occurs first.*
oRotate tires.
oReplace the engine air filter.
oInspect the transfer case fluid; change if using your vehicle for any of the following:
police, taxi, fleet or frequent trailer towing.
oInspect the brake linings; replace if necessary.
oFlush and replace the engine coolant at 60 months if not done at 170 000 km.
oChange the automatic transmission fluid and filter if using your vehicle for any of
the following: police, taxi, fleet or frequent trailer towing.
* Oil changes that are prompted by the oil change indicator system prior to this
schedule maintenance interval can be recorded in the oil change log section.
Perform Maintenance
At
60 Months or
100,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................

JOBNAME: 146224AspenHEV 2009 PAGE: 20 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/intervals
oChange the engine oil and oil filter.Under no circum-
stances should the oil change interval exceed 10 000 km
or 6 months whichever occurs first.*
oRotate tires.
oReplace the engine air filter.
oInspect the transfer case fluid; change if using your vehicle
for any of the following: police, taxi, fleet or frequent
trailer towing.
oInspect the brake linings; replace if necessary.
oFlush and replace the engine coolant at 60 months if not
done at 170 000 km.
oChange the automatic transmission fluid and filter if using
your vehicle for any of the following: police, taxi, fleet or
frequent trailer towing.
* Oil changes that are prompted by the oil change indicator
system prior to this schedule maintenance interval can be
recorded in the oil change log section.
Perform Maintenance At
100,000 km or 60 Months
Odometer Reading
Date
Repair Order No.
CHRYSLER
RETAILERSTAMP
Signature of authorized Chrysler Canada Retailer
................................................................................................

JOBNAME: 146224AspenHEV 2009 PAGE: 23 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/intervals
Perform Maintenance At
120,000 km or 72 Months
oChange the engine oil and oil filter.Under no circumstances should the oil change
interval exceed 10 000 km or 6 months whichever occurs first.*
oRotate tires.
oInspect the engine air filter if using your vehicle in dusty or off-road conditions;
replace if necessary.
oInspect the front and rear axle fluid; change if using your vehicle for any of the
following: police, taxi, fleet, off-road or frequent trailer towing.
oInspect the front suspension components, tie rod ends and boot seals; replace if
necessary.
oInspect the brake linings; replace if necessary.
oInspect the CV joints.
oInspect the exhaust system.
* Oil changes that are prompted by the oil change indicator system prior to this
schedule maintenance interval can be recorded in the oil change log section.
Perform Maintenance
At
72 Months or
120,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................

JOBNAME: 146224AspenHEV 2009 PAGE: 24 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/intervals
oChange the engine oil and oil filter.Under no circum-
stances should the oil change interval exceed 10 000 km
or 6 months whichever occurs first.*
oRotate tires.
oInspect the engine air filter if using your vehicle in dusty
or off-road conditions; replace if necessary.
oInspect the front and rear axle fluid; change if using your
vehicle for any of the following: police, taxi, fleet, off-road
or frequent trailer towing.
oInspect the front suspension components, tie rod ends and
boot seals; replace if necessary.
oInspect the brake linings; replace if necessary.
oInspect the CV joints.
oInspect the exhaust system.
* Oil changes that are prompted by the oil change indicator
system prior to this schedule maintenance interval can be
recorded in the oil change log section.
Perform Maintenance At
120,000 km or 72 Months
Odometer Reading
Date
Repair Order No.
CHRYSLER
RETAILERSTAMP
Signature of authorized Chrysler Canada Retailer
................................................................................................

JOBNAME: 146224AspenHEV 2009 PAGE: 35 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/intervals
Perform Maintenance At
180,000 km or 108 Months
oChange the engine oil and oil filter.Under no circumstances should the oil change
interval exceed 10 000 km or 6 months whichever occurs first.*
oRotate tires.
oInspect the engine air filter if using your vehicle in dusty or off-road conditions;
replace if necessary.
oInspect the front and rear axle fluid; change if using your vehicle for any of the
following: police, taxi, fleet, off-road or frequent trailer towing.
oInspect the brake linings; replace if necessary.
* Oil changes that are prompted by the oil change indicator system prior to this
schedule maintenance interval can be recorded in the oil change log section.
Perform Maintenance
At
108 Months or
180,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................

JOBNAME: 146224AspenHEV 2009 PAGE: 36 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/intervals
oChange the engine oil and oil filter.Under no circum-
stances should the oil change interval exceed 10 000 km
or 6 months whichever occurs first.*
oRotate tires.
oInspect the engine air filter if using your vehicle in dusty
or off-road conditions; replace if necessary.
oInspect the front and rear axle fluid; change if using your
vehicle for any of the following: police, taxi, fleet, off-road
or frequent trailer towing.
oInspect the brake linings; replace if necessary.
* Oil changes that are prompted by the oil change indicator
system prior to this schedule maintenance interval can be
recorded in the oil change log section.
Perform Maintenance At
180,000 km or 108 Months
Odometer Reading
Date
Repair Order No.
CHRYSLER
RETAILERSTAMP
Signature of authorized Chrysler Canada Retailer
................................................................................................

JOBNAME: 146224AspenHEV 2009 PAGE: 39 SESS: 13 OUTPUT: Thu Jul 10 15:40:34 2008
/chrysler/chry-intl/warr-maint/146224-hghev-english/intervals
Perform Maintenance At
200,000 km or 120 Months
oChange the engine oil and oil filter.Under no circumstances should the oil change
interval exceed 10 000 km or 6 months whichever occurs first.*
oRotate tires.
oReplace the engine air filter.
oInspect the front suspension components, tie rod ends and boot seals; replace if
necessary.
oInspect the transfer case fluid; change if using your vehicle for any of the following:
police, taxi, fleet or frequent trailer towing.
oInspect the brake linings; replace if necessary.
oInspect the CV joints.
oInspect the exhaust system.
oChange the automatic transmission fluid and filter.
oReplace the accessory drive belt(s).
* Oil changes that are prompted by the oil change indicator system prior to this
schedule maintenance interval can be recorded in the oil change log section.
Perform Maintenance
At
120 Months or
200,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................